<abstract xmlns="http://www.w3.org/1999/xhtml"><p>The aim of the present study was to gain further understanding of the precursors in tobacco of four polycyclic aromatic amines (PAAs) - 1- and 2-aminonaphthalene, 3- and 4-aminobiphenyl. We carried out non-isothermal pyrolysis of the residues, which were obtained after extraction of tobacco cut filler with methylene chloride followed by extraction with water, under three different pyrolysis conditions (target temperature 800 °C / 800 °C / 400 °C and O<sub>2</sub> concentration in carrier gas 0% / 20% / 3%, resp.). The yields of the four PAAs obtained by the pyrolysis of each sample were evaluated. Several nitrogenous components in the sample were also analyzed. The results under all these pyrolysis conditions showed that 1) the methylene chloride-soluble fraction, in which 50-60% of nicotine was extracted, did NOT contribute significantly contribution to the yields of the four PAAs; 2) the watersoluble fraction, in which most of the nitrogenous inorganic ions and amino acids were extracted, contributed at an average of about 30% to total PAA yield; and 3) the insoluble residue, in which only protein was detected during the investigation of the nitrogenous components in the present study, showed the highest contribution, 50-60% of the four PAAs formed. Consequently, it is concluded that protein-like components in tobacco contribute highly to the formation of the four PAAs by tobacco pyrolysis.</p></abstract>

The aim of the present study was to gain further understanding of the precursors in tobacco of four polycyclic aromatic amines (PAAs) - 1- and 2-aminonaphthalene, 3- and 4-aminobiphenyl. We carried out non-isothermal pyrolysis of the residues, which were obtained after extraction of tobacco cut filler with methylene chloride followed by extraction with water, under three different pyrolysis conditions (target temperature 800 °C / 800 °C / 400 °C and O2 concentration in carrier gas 0% / 20% / 3%, resp.). The yields of the four PAAs obtained by the pyrolysis of each sample were evaluated. Several nitrogenous components in the sample were also analyzed. The results under all these pyrolysis conditions showed that 1) the methylene chloride-soluble fraction, in which 50-60% of nicotine was extracted, did NOT contribute significantly contribution to the yields of the four PAAs; 2) the watersoluble fraction, in which most of the nitrogenous inorganic ions and amino acids were extracted, contributed at an average of about 30% to total PAA yield; and 3) the insoluble residue, in which only protein was detected during the investigation of the nitrogenous components in the present study, showed the highest contribution, 50-60% of the four PAAs formed. Consequently, it is concluded that protein-like components in tobacco contribute highly to the formation of the four PAAs by tobacco pyrolysis.

Roles of Tobacco Fractions in the Formation of Polycyclic Aromatic Amines in Tobacco Pyrolysis

Tobacco Science Research Center, Japan Tobacco Inc., Yokohama, Kanagawa, Japan

Graduate School of Engineering, Yokohama National University, Yokohama, Kanagawa, Japan

Contributions to Tobacco & Nicotine Research

This work is licensed under the Creative Commons Attribution-NonCommercial-NoDerivatives 3.0 License.

The aim of the present study was to gain further understanding of the precursors in tobacco of four polycyclic aromatic amines (PAAs) - 1- and...

Roles of Tobacco Fractions in the Formation of Polycyclic Aromatic Amines in Tobacco Pyrolysis

Data publikacji: 30 gru 2014

Zakres stron: 595 - 606

Otrzymano: 15 sty 2013

Przyjęty: 07 maj 2013

DOI: https://doi.org/10.2478/cttr-2013-0936

© 2013 Beiträge zur Tabakforschung International

This work is licensed under the Creative Commons Attribution-NonCommercial-NoDerivatives 3.0 License.