<abstract xmlns="http://www.w3.org/1999/xhtml">

<p>Canadian tobacco was flue-cured using two different heating systems: direct-fired in which the exhaust gases were in contact with the tobacco and indirect in which only hot air, via a heat exchanger, contacted the tobacco. The concentrations of tobacco-specific nitrosamines (TSNAs) in tobacco cured by indirect heating did not increase during curing and were in the range 0.25-0.35 ppm. There were no changes in TSNA concentrations (range 0.13-0.3 ppm) in tobacco cured by direct firing during the first six days (0-144 h) of curing. However between 168 and 264 h, significant increases in TSNAs occurred (up to 1.91 ppm). TSNA concentrations in leaves at the bottom of the plant were significantly higher than in those found at higher plant position. There were no significant differences in TSNA concentrations in tobacco cured on different farms. The TSNA concentrations in tobacco cured by indirect heat were 87% ± 5% lower than in tobacco cured by direct heat. Subsequent processing of tobacco did not change the relative concentrations of TSNAs.</p>
</abstract>

Canadian tobacco was flue-cured using two different heating systems: direct-fired in which the exhaust gases were in contact with the tobacco and indirect in which only hot air, via a heat exchanger, contacted the tobacco. The concentrations of tobacco-specific nitrosamines (TSNAs) in tobacco cured by indirect heating did not increase during curing and were in the range 0.25-0.35 ppm. There were no changes in TSNA concentrations (range 0.13-0.3 ppm) in tobacco cured by direct firing during the first six days (0-144 h) of curing. However between 168 and 264 h, significant increases in TSNAs occurred (up to 1.91 ppm). TSNA concentrations in leaves at the bottom of the plant were significantly higher than in those found at higher plant position. There were no significant differences in TSNA concentrations in tobacco cured on different farms. The TSNA concentrations in tobacco cured by indirect heat were 87% ± 5% lower than in tobacco cured by direct heat. Subsequent processing of tobacco did not change the relative concentrations of TSNAs.

Evolution of Tobacco-Specific Nitrosamines and Microbial Populations During Flue-Curing of Tobacco Under Direct and Indirect Heating

Imperial Tobacco Canada Limited, Montreal, Quebec, H4C 3P6, Canada

Imperial Tobacco Leaf Inc., Aylmer, Ontario, N5H 2R8, Canada

Contributions to Tobacco & Nicotine Research

This work is licensed under the Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.

Canadian tobacco was flue-cured using two different heating systems: direct-fired in which the exhaust gases were in contact with the tobacco and indirect in...

Evolution of Tobacco-Specific Nitrosamines and Microbial Populations During Flue-Curing of Tobacco Under Direct and Indirect Heating

Publicado en línea: 30 dic 2014

Páginas: 40 - 46

Recibido: 22 ago 2003

Aceptado: 23 dic 2003

DOI: https://doi.org/10.2478/cttr-2013-0770

© 2004 Beiträge zur Tabakforschung International

This work is licensed under the Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.